Diabase from Drača open pit mine in central Serbia - quality assessment for building stone purposes

Vast masses of basic rocks are present as tectonic blocks and slices along the Eastern deep fault of the Vardar zone of Serbia. They are predominantly comprised of gabbro, with smaller part made up of diabase, and occurrences of granite, aplite and pegmatite dykes. Basic rock masses are trending along the line Kragujevac (Ždraljica)-Velika Pčelica-Bogalinac ~8 km west of Rekovac. A significantly smaller diabase massif is present along the same tectonic line, further toward SE, at Prevešt village by Kalenicka River, approximately 13 km south of Rekovac. Drača open pit mine is situated in this diabase massif. Geologic explorative works have confirmed the reserves of 1 846 695 t of stone mass for building purposes. For over a decade, Draca mine has been producing various types of building stone, mainly graded stone aggregate with favourable physico-mechanical properties for road-construction works. Chemical analyses and petrographic study have shown typical composition and fabric for this type of rock. Main constituents are plagioclase and pyroxene, with opaque minerals as accessory and varying secondary minerals – chlorite, calcite, in some places epidote and limonite. Pyrite enrichment is visible in some areas of the massif. Chlorite, calcite, epidote and pyrite are the products of propylitic alteration. Although products of alteration are present throughout the rock mass with variable intensity, as is typical for the basic rocks of the former ocean floor sequences, petrologic properties are favourable for building stone purposes. Physico-mechanical properties of diabase have favourable values and varying scattering degrees. Dry state uniaxial compressive strength average values from seven analyses vary in the range 130-169 MPa. Resistance to abrasion average values vary in the range 9.04-17.07 cm³/50cm². Apparent density varies within the span 2759-2926 g/cm³ and real density 2804-2951 g/cm³. Water absorption values 0.08-1.04 %. Resistance to weathering through testing of stability using Sodium-sulphate values vary from 0.00 to 0.15 % and through frost resistance from 0.00 to 0.04 %. Porosity values are almost constant at 0.8 %. In more altered parts of the rock mass, porosity reaches 1.6 %. Graded crushed aggregate has favourable values of Los Angeles coefficient 14.2 and 14.3 % for gradation B. Taking into consideration all performed tests and analyses, it is concluded that diabase from Drača mine can be used as a building stone for production of aggregate for use in concrete and for road-construction (asphalt paving mixtures for moderate, light and very light traffic load as a top wearing layer; for lower and upper bearing layers; for classic and modern road foundations); for production of crushed and hewn stone for building; crushed stone for railroad ballast. Also, it can be and is used as a raw material for production of stone wool for thermal insulation purposes.

Dieses Werk wurde unter der Creative-Commons-Lizenz Namensnennung 3.0 (CC-BY 3.0) veröffentlicht und darf unter den Lizenzbedinungen vervielfältigt, verbreitet, öffentlich zugänglich gemacht, sowie abgewandelt und bearbeitet werden. Dabei muss der Urheber bzw. Rechteinhaber genannt und die Lizenzbedingungen eingehalten werden.